Upper Flammability Limits of Methane/Air Mixtures at Elevated Temperature and Pressure
6 affiliations
- 1Xinjiang Institute of Engineering , , ,
- 2Zhundong Economic and Technological Development Zone , , ,
- 3Xinjiang Yihua Mining Co., Ltd. , ,
- 4Henan Polytechnic University , , ,
- 5State Key Laboratory of Chemical Safety , ,
- 6SINOPEC Research Institute of Safety Engineering Co. Ltd. , ,
Abstract
Methane/air mixtures in preheated and pressurized process equipment may exhibit a broadened flammability envelope, which is critical for explosion-hazard assessment and safety-envelope definition. Reliable upper flammability limit (UFL) data under elevated-temperature and elevated-pressure conditions are therefore needed for methane-related industrial systems. In this work, the UFLs of methane/air mixtures were measured in a 20 L closed spherical vessel at initial temperatures of 25–100 °C and pressures of 0.1–1.0 MPa in accordance with EN 17624:2022 and GB/T 42368–2023. Within the investigated range, the UFL increases approximately linearly with temperature and logarithmically with pressure. Under simultaneous temperature and pressure elevation, the increase in UFL is greater than that estimated from the simple superposition of their individual effects, indicating a non-negligible interaction between the two parameters. Based on the full experimental matrix, an empirical correlation incorporating a temperature–pressure interaction term is proposed to represent the UFL surface and shows good agreement with the experimental data. Chemical-kinetic simulations using USC Mech II were performed to assist interpretation of the experimental trends. The normalized sensitivity analysis identifies temperature-promoted branching pathways and pressure-enhanced radical stabilization/recombination pathways as the principal competing kinetic tendencies near the UFL. The present work provides a protocol-compliant methane/air UFL data set and a practical correlation for preheated and pressurized methane systems.
Related
- Pressure and temperature dependence of methane pyrolysis and hydrogen production in a micro flow reactor
- Molecular origin of pressure-induced re-entrant phase separation of CO₂–H₂O mixtures
- Food additive mixtures and incident elevated depressive symptoms in the NutriNet-Santé cohort
- Optimization of electrochemical reduction of high-pressure CO₂ to hydrocarbon (methane) at nickel electrode in cold methanol.
- Laser-Structured Nickel Electrodes for Enhanced Hydrogen Evolution Kinetics in Alkaline Media at Elevated Temperature.
BibTeX
@article{wang2026upper,
title = {{Upper Flammability Limits of Methane/Air Mixtures at Elevated Temperature and Pressure}},
author = {Yue Wang and Jinfeng Mao and Afang Gu and Chang Yuan and Chang Qi},
journal = {ACS Omega},
year = {2026},
month = oct,
doi = {10.1021/acsomega.6c03983},
url = {https://pubs.acs.org/acsodf/article/11/41/62677/5448449/Upper-Flammability-Limits-of-Methane-Air-Mixtures},
note = {CC BY-NC-ND 4.0},
}
RIS
TY - JOUR
TI - Upper Flammability Limits of Methane/Air Mixtures at Elevated Temperature and Pressure
AU - Yue Wang
AU - Jinfeng Mao
AU - Afang Gu
AU - Chang Yuan
AU - Chang Qi
PY - 2026
DA - 2026/10/10
JO - ACS Omega
DO - 10.1021/acsomega.6c03983
UR - https://pubs.acs.org/acsodf/article/11/41/62677/5448449/Upper-Flammability-Limits-of-Methane-Air-Mixtures
AB - Methane/air mixtures in preheated and pressurized process equipment may exhibit a broadened flammability envelope, which is critical for explosion-hazard assessment and safety-envelope definition. Reliable upper flammability limit (UFL) data under elevated-temperature and elevated-pressure conditions are therefore needed for methane-related industrial systems. In this work, the UFLs of methane/air mixtures were measured in a 20 L closed spherical vessel at initial temperatures of 25–100 °C and pressures of 0.1–1.0 MPa in accordance with EN 17624:2022 and GB/T 42368–2023. Within the investigated range, the UFL increases approximately linearly with temperature and logarithmically with pressure. Under simultaneous temperature and pressure elevation, the increase in UFL is greater than that estimated from the simple superposition of their individual effects, indicating a non-negligible interaction between the two parameters. Based on the full experimental matrix, an empirical correlation incorporating a temperature–pressure interaction term is proposed to represent the UFL surface and shows good agreement with the experimental data. Chemical-kinetic simulations using USC Mech II were performed to assist interpretation of the experimental trends. The normalized sensitivity analysis identifies temperature-promoted branching pathways and pressure-enhanced radical stabilization/recombination pathways as the principal competing kinetic tendencies near the UFL. The present work provides a protocol-compliant methane/air UFL data set and a practical correlation for preheated and pressurized methane systems.
SN - 2470-1343
ER -